Schaefer WayCool Manuel d'utilisateur

Portable Evaporative CoolerWayCool® 1HP MFA SeriesUSER'S MANUALWC-1HPMFA WC-1HPMFA360WC-1HPMFAOSCWCG-1HPMFA

Blower and DuctworkThe WayCool® evaporative cooler uses a belt-driven, 1 HP electric motor to drive a centrifugal blower. Theblower draws room air thr

ControlThe WayCool® control switch is mounted on the outside of one frame leg.It has the following positions:OFF power is off to the blower motor and

Operation and Maintenance cont'dUNPACKING AND INITIAL SETUPThe WayCool® is shipped upright in a corrugated container. The unit is fully assembled

Operation and Maintenance cont'dREGULAR CLEANINGThe frequency with which the WayCool® should be cleaned will depend on the environment in which i

TroubleshootingCOOLING PADS NOT WETTING1. Ensure there is water in the reservoir.2. Ensure the motor switch is in the START position and the pump swit

Options and AccessoriesYour WayCool® can be purchased with certain options and/or accessories, and some of these can be retrofittedafter the initial p

OSCILLATING SPOUTThe oscillating spout is operated by a four RPM gear motor that delivers 50 in/lbs. of torque. As the gear motor rotates, the spout o

Warranty17All information, illustrations and specifications provided here are based on the latest product information available at the time of printin

www.schaeferfan.com©2011 Schaefer Ventilation Equipment / M-WC1HPMFA 9-6-11

INTRODUCTION ...3Why use evap

IntroductionWHY USE EVAPORATIVE COOLERS IN YOUR WORKPLACE• The WayCool® evaporative cooler requires little space, has a low initial cost, is inexpensi

About This ManualThe intent of this manual is to help you in two ways: to provide you with step-by-step instructions for quick andeasy assembly of you

5Safety RecommendationsPLEASE NOTEMinimum inlet pressure is 10 PSI; maximum inlet pressure is 100 PSI.Never leave unit unattended while in operation.R

DescriptionThe WayCool® evaporative cooler is a completely self-contained, portable unit capable of delivering 40 MPHvelocity of air with a temperatur

Water Supply SystemThe reservoir can be supplied continuously with an ordinary garden hose by attaching the supplied hose adapterto the fill connectio

Water Supply System cont'dA drain in the reservoir allows you to drain the unit for cleaning and maintenance. A drain cap on the undersideof the

Cooling Pad AssemblyThe cooling pads are critical for proper, efficient cooler operation. They are made of laminated cellulose (paper)fibers and arran